UK PCV Theory Test Daily Checks and Maintenance 1

Question 1

During your walk-around check you notice that several plastic wheel-nut rotation indicators are no longer aligned with each other. What does this indicate?

Accepted Answer

The wheel nuts may have loosened since they were last tightened

Answer

Wheel-nut rotation indicators are fitted so that any movement of a nut causes the pointer to move out of alignment with its neighbours. Misalignment is a warning that nuts may have worked loose, which is a serious safety hazard requiring immediate attention before the vehicle is driven.

Question 2

When carrying out your daily engine oil level check, what is the correct condition of the vehicle before taking the reading?

Accepted Answer

On level ground with the engine switched off and oil settled

Answer

The dipstick must be read with the engine off so oil has drained back into the sump and is not circulating or splashing. The vehicle must also be on level ground to ensure an accurate reading; a slope will give a false high or low indication.

Question 3

Under UK regulations, what is the minimum capacity dry-powder fire extinguisher that must be carried on a PCV used for the public carriage of passengers?

Accepted Answer

2 kg

Answer

UK PSV (Public Service Vehicle) regulations require that PCVs carry at least a 2 kg dry-powder fire extinguisher (or an approved equivalent). It must be in a serviceable condition, properly mounted, and accessible to the driver or crew.

Question 4

While building air pressure after starting the engine, you notice the low-pressure warning buzzer and light remain active and the gauge does not reach the required operating level. What is the correct action?

Accepted Answer

Switch the engine off, report the defect, and take the vehicle out of service

Answer

An air-brake system that fails to reach operating pressure means the brakes may not perform correctly. The vehicle must not be driven until the fault is diagnosed and repaired. Driving with defective air brakes risks total brake failure and is illegal.

Question 5

Which of the following must you verify is in correct working order and completely unobstructed as part of your daily PCV pre-departure check?

Accepted Answer

All emergency exit doors and their release mechanisms

Answer

Emergency exits — including rear doors, roof hatches, and side emergency windows — must open freely from both inside and outside, be clearly marked, and have clear gangway access. Blocked or defective emergency exits endanger lives if evacuation is needed.

UK PCV Theory Practice Test

UK PCV Theory Practice Test

UK PCV Theory Test Daily Checks and Maintenance 1