GM GM HVAC and Climate Control 2

Question 1

What DTC would typically indicate a faulty blend door actuator on a GM vehicle?

Accepted Answer

B0223 or similar B-code related to the HVAC actuator position

Answer

Blend door actuator faults are reported as B-prefix body DTCs (e.g., B0223) related to the HVAC temperature door position sensor or motor circuit.

Question 2

How should a GM technician verify the correct refrigerant charge after an AC system recharge?

Accepted Answer

By measuring high and low side pressures and comparing to temperature-pressure charts

Answer

Proper charge verification requires measuring both high and low side pressures with a manifold gauge set and comparing readings to the temperature-pressure chart for the specific refrigerant.

Question 3

What is the function of the GM HVAC system's recirculation mode?

Accepted Answer

Recirculates cabin air to improve cooling efficiency and block outside odors

Answer

Recirculation mode closes the outside air inlet and recirculates interior cabin air, which is already cooled and allows the AC to reach target temperature faster while blocking outside odors.

Question 4

A GM vehicle's automatic climate control is not responding to temperature inputs. The blower operates normally. Which component should be diagnosed first?

Accepted Answer

The HVAC control module and blend door actuators

Answer

When blower function is normal but temperature control is unresponsive, the HVAC control module and blend door actuators should be diagnosed as they govern temperature door positioning.

Question 5

Which GM component cycles the AC compressor on and off to prevent evaporator freeze-up on systems without an expansion valve?

Accepted Answer

Pressure cycling switch

Answer

The pressure cycling switch monitors low-side pressure and cycles the compressor off when pressure drops too low (indicating near-freeze conditions) to prevent evaporator icing.

(GM) General Motors Certified Practice Test

(GM) General Motors Certified Practice Test

GM GM HVAC and Climate Control 2