CFA Aisle Navigation & Right-of-Way 5

Question 1

A supervisor verbally instructs a forklift operator to travel through an aisle marked 'Closed for Maintenance.' What should the operator do?

Accepted Answer

Refuse and suggest an alternate route, as maintenance closures protect workers in the aisle

Answer

Aisle closures exist to protect maintenance workers whose lives would be endangered by forklift traffic; no verbal instruction overrides this safety control.

Question 2

What is the primary reason forklifts should travel with the load lowered to the travel position (6–8 inches off the floor) in aisles?

Accepted Answer

To lower the center of gravity and improve stability during travel

Answer

Traveling with the load in the lowered position keeps the center of gravity low, dramatically improving stability and reducing tip-over risk.

Question 3

How should a forklift operator handle an aisle where a partially opened roll-up door reduces headroom to below the mast height?

Accepted Answer

Stop and do not enter until the door is fully opened or an alternate route is found

Answer

Entering an aisle with insufficient overhead clearance risks striking the door, damaging the mast, and potentially tipping the forklift — the operator must not enter.

Question 4

A visiting contractor's worker is walking through a forklift aisle without a high-visibility vest. What must the operator do?

Accepted Answer

Slow down, yield to the pedestrian, and notify a supervisor about the PPE violation

Answer

Operators must always yield to pedestrians regardless of PPE status, and the PPE violation should be reported to a supervisor to prevent future risk.

Question 5

When operating a forklift in an aisle with overhead conveyors or hanging obstacles, what is the operator's primary responsibility?

Accepted Answer

Know the forklift's maximum raised mast height and ensure clearance before entering

Answer

Operators must know their equipment's dimensions and verify overhead clearance before entering any area with hanging infrastructure.

CFA Practice Test

CFA Practice Test

CFA Aisle Navigation & Right-of-Way 5