CFA Aisle Navigation & Right-of-Way 5

Question 1

A supervisor verbally instructs a forklift operator to travel through an aisle marked 'Closed for Maintenance.' What should the operator do?

Accepted Answer

Refuse and suggest an alternate route, as maintenance closures protect workers in the aisle

Answer

Follow the supervisor's instructions since supervisors override signage

Answer

Proceed slowly with headlights on

Answer

Complete the task quickly before maintenance workers notice

Question 2

What is the primary reason forklifts should travel with the load lowered to the travel position (6–8 inches off the floor) in aisles?

Accepted Answer

To lower the center of gravity and improve stability during travel

Answer

To reduce drag and improve fuel efficiency

Answer

To comply with maximum height restrictions in aisles

Answer

To make it easier to spot floor hazards under the load

Question 3

How should a forklift operator handle an aisle where a partially opened roll-up door reduces headroom to below the mast height?

Accepted Answer

Stop and do not enter until the door is fully opened or an alternate route is found

Answer

Lower the mast and proceed at speed

Answer

Tilt the mast back to reduce effective height and proceed

Answer

Sound the horn and proceed slowly watching for clearance

Question 4

A visiting contractor's worker is walking through a forklift aisle without a high-visibility vest. What must the operator do?

Accepted Answer

Slow down, yield to the pedestrian, and notify a supervisor about the PPE violation

Answer

Proceed normally since the contractor is responsible for their worker's PPE

Answer

Sound the horn loudly to signal the worker to move faster

Answer

Stop and refuse to move until the worker leaves the area permanently

Question 5

When operating a forklift in an aisle with overhead conveyors or hanging obstacles, what is the operator's primary responsibility?

Accepted Answer

Know the forklift's maximum raised mast height and ensure clearance before entering

Answer

Travel faster to minimize time under the obstacles

Answer

Sound the horn at regular intervals under overhead obstacles

Answer

Always travel with the load tilted forward under overhead obstacles

Question 6

In a multi-level warehouse with ramps connecting floors, what right-of-way rule applies to forklift ramp traffic?

Accepted Answer

Loaded forklifts ascending have right-of-way over empty forklifts descending

Answer

The first forklift to reach the ramp proceeds regardless of direction

Answer

Descending forklifts always have right-of-way

Answer

Right-of-way is determined by seniority of the operator

Question 7

A forklift operator notices that a safety mirror at an aisle intersection is cracked and provides a distorted view. What is the correct action?

Accepted Answer

Report the mirror as damaged immediately and treat the intersection as a blind corner until repaired

Answer

Use the mirror at reduced confidence and proceed with extra care

Answer

Remove the mirror to avoid confusion from distorted reflections

Answer

Use the horn more frequently as a substitute for the mirror