Certified Energy Auditor Certification Certified Energy Auditor HVAC Systems and Controls 1

Question 1

A variable frequency drive (VFD) is installed on a centrifugal fan operating in an HVAC system. If the fan speed is reduced to 80% of its rated speed, by approximately what percentage does fan power consumption decrease?

Accepted Answer

49%

Answer

Centrifugal fan power follows the Affinity Laws: power varies as the cube of speed. (0.8)³ = 0.512, meaning power drops to about 51% of original — a reduction of approximately 49%. This is why VFDs yield dramatic energy savings even with modest speed reductions.

Question 2

During an energy audit of a large office building, CO2 concentrations in occupied zones average 1,400 ppm despite ASHRAE 62.1 specifying 1,100 ppm as a guideline threshold above background. The most energy-efficient corrective action is:

Accepted Answer

Install demand-controlled ventilation (DCV) using CO2 sensors to modulate outside air

Answer

Demand-controlled ventilation uses CO2 sensors to modulate outside air intake based on actual occupancy, delivering just enough fresh air to maintain acceptable indoor air quality without conditioning excess outside air. This corrects the IAQ problem while minimizing the energy penalty of over-ventilation.

Question 3

An energy auditor measures the approach temperature of a cooling tower and finds it is 12°F above the design specification of 4°F. Which condition most likely explains this?

Accepted Answer

Cooling tower fill is fouled or partially blocked

Answer

Approach temperature is the difference between the leaving water temperature and the ambient wet-bulb temperature. Fouled or blocked fill reduces heat and mass transfer between water and air, raising the leaving water temperature and increasing the approach temperature well above design.

Question 4

An air-handling unit serving a hospital serves both interior and perimeter zones simultaneously year-round. An auditor identifies significant reheat energy waste. Which energy recovery technology would best reduce both heating and cooling energy at this AHU?

Accepted Answer

Energy recovery ventilator (ERV) with an enthalpy wheel

Answer

An enthalpy wheel ERV transfers both sensible heat and latent moisture between exhaust and supply air streams, pre-conditioning incoming outside air with energy that would otherwise be discarded. In a hospital with high mandatory outside air requirements, this dramatically cuts both heating and cooling loads.

Question 5

During a duct leakage test on a packaged rooftop unit, a technician measures total leakage of 22% of system airflow. ASHRAE Standard 90.1 typically requires sealing when leakage exceeds 4% for new construction. What is the primary energy impact of excessive duct leakage in a supply duct located in an unconditioned attic?

Accepted Answer

Conditioned air is lost to an unconditioned space, forcing the system to run longer to meet setpoint

Answer

Supply duct leakage in an unconditioned attic means conditioned air bypasses the occupied zone entirely. The thermostat never sees that delivered energy, so the system runs longer to satisfy the setpoint — directly wasting both fan and compressor energy proportional to the leakage fraction.

Certified Energy Auditor Certification Practice Test

Certified Energy Auditor Certification Practice Test

Certified Energy Auditor Certification Certified Energy Auditor HVAC Systems and Controls 1