PITO Ramp, Grade & Dock Operations 3

Question 1

What is the primary danger of traveling too fast on a ramp with a loaded forklift?

Accepted Answer

Loss of directional control and tip-over risk when stopping or turning

Answer

Increased tire wear from the incline friction

Answer

Reduced battery life in electric forklifts on grades

Answer

Overheating of the mast hydraulic cylinders

Question 2

If an operator must stop a loaded forklift on a ramp due to an emergency, they should:

Accepted Answer

Apply the brake, set the parking brake, and lower forks to the ramp surface if possible

Answer

Abandon the forklift and warn nearby workers immediately

Answer

Tilt the mast forward to lower the center of gravity

Answer

Shift to neutral and use the horn to alert bystanders

Question 3

Which of the following is an essential dock safety practice before a forklift enters a trailer?

Accepted Answer

Engage a trailer restraint device (ICC bar hook) in addition to wheel chocks

Answer

Leave the dock light green until the forklift has fully exited the trailer

Answer

Remove the dock leveler after the forklift enters to prevent trailer creep

Answer

Ensure the trailer's landing gear is retracted to prevent interference

Question 4

What is the purpose of a communication light system at a loading dock?

Accepted Answer

To signal to the truck driver whether it is safe to move the trailer

Answer

To illuminate the inside of the trailer for the forklift operator

Answer

To alert pedestrians that a forklift is entering or exiting the dock area

Answer

To indicate the forklift's battery charge level during long loading operations

Question 5

Under which condition should a forklift operator refuse to operate on a ramp or grade?

Accepted Answer

When the ramp surface is wet, icy, or exceeds the forklift's rated grade

Answer

When the load is at or below 50% of the forklift's rated capacity

Answer

When the ramp is longer than 20 feet

Answer

When no spotter is available to observe the descent

Question 6

Before a forklift operator crosses a portable dock plate (bridge plate), they must confirm:

Accepted Answer

The dock plate's capacity rating equals or exceeds the combined weight of the forklift and its load

Answer

The dock plate is painted a high-visibility color

Answer

The dock plate surface is at least 4 feet wide

Answer

The dock plate is permanently welded to the dock edge

Question 7

When parking a forklift near a loading dock edge at the end of an operation, the operator should:

Accepted Answer

Park at least 2 feet back from the dock edge with the parking brake set

Answer

Park as close to the edge as possible to keep the aisle clear

Answer

Position the forklift perpendicular to the dock edge for stability

Answer

Leave the engine running so the next operator can begin immediately