OIT Basic Operation and Controls 3

Question 1

What is the recommended travel speed for a forklift in areas where pedestrians may be present?

Accepted Answer

5 mph or walking speed

Answer

In pedestrian areas, forklifts should travel at approximately walking speed (3–5 mph) to allow adequate stopping distance.

Question 2

If a forklift's steering feels unusually loose or unresponsive, the operator should:

Accepted Answer

Report it and remove the truck from service

Answer

Loose or unresponsive steering is a safety defect that requires the truck to be taken out of service and reported to a supervisor.

Question 3

The maximum fork height for traveling with a load on level ground is:

Accepted Answer

6 inches (150 mm) above the floor

Answer

Loads should be carried 6 inches (150 mm) above the floor to maintain stability and adequate clearance without raising the center of gravity.

Question 4

Which of the following actions can cause a rear-wheel-steered forklift to tip sideways?

Accepted Answer

Turning sharply at excessive speed

Answer

Sharp turns at high speeds cause lateral forces that can exceed the forklift's stability limits, leading to a side tip.

Question 5

What does a red light on the battery discharge indicator of an electric forklift typically indicate?

Accepted Answer

Battery has reached 20% or less and requires charging soon

Answer

A red indicator on the discharge gauge warns the operator that battery charge is critically low and the truck should be taken for recharging.

(OIT) Operator in Training Practice Test